Any government or Indian tribe (or an agency or instrumentality of any government or Indian tribe) that transports hazardous material for a governmental purpose. The shipping name of the material being transported; The UN/ID number of the material; . Any non-specification package that displays the ISTA seal indicating the package has been tested and certified to ISTA Procedure 3A is not subject to the minimum ECT or burst strength requirements. Orientation arrows not required on single packagings. (a) Except for size and color, the DANGEROUS WHEN WET placard must be as follows: (b) In addition to complying with 172.519, the background color on the DANGEROUS WHEN WET placard must be blue. Service Alert Due to Situation in Ukraine, UPS Variations: Mode-Specific Requirements, UPS Variations: Class-Specific or Commodity-Specific Limitations, Do Not Sell or Share My Personal Information, All hazardous materials shippers must process their shipments using a UPS-compliant shipping solution in conjunction with hazardous materials shipment preparation software. (a) Except for size and color, the EXPLOSIVES 1.1, EXPLOSIVES 1.2 and EXPLOSIVES 1.3 placards must be as follows: (b) In addition to complying with 172.519 of this subpart, the background color on the EXPLOSIVES 1.1, EXPLOSIVES 1.2, and EXPLOSIVES 1.3 placards must be orange. Applicability of placarding requirements 172.500: Placarding is not required for infectious substances, ORM-D, limited quantities, small quantity shipments, and combustible liquids in non-bulk packages. "Dangerous when wet" material means a material that, by contact with water, is liable to become spontaneously flammable. The inscription must be black with the 18-inch (3.2 mm.) site when drafting amendatory language for Federal regulations: "However, when 2,205 pounds or more of one category of materials is. The basic marking requirement consists of the proper shipping name and identification number of the hazardous materials contained in the package. (c) The word GASOLINE may be used in place of the word FLAMMABLE on a placard that is displayed on a cargo tank or a portable tank being used to transport gasoline by highway. What kind of hazardous materials can be transported by HMSP? 15, 1976, as amended by Amdt. DIVISION 2.2 NON-FLAMMABLE GASES For shipments of UN3171 powered by lithium batteries, UPS requires the additional marking, "Contains Lithium Batteries." All fully regulated shipments of Division 4.3 (Dangerous When Wet) materials, when offered at air or ground service levels. (a) Except for size and color, the EXPLOSIVES 1.4 placard must be as follows: (b) In addition to complying with 172.519 of this subpart, the background color on the EXPLOSIVES 1.4 placard must be orange. Records may be in any format such as paper or electronic files as long as they contain the required information and are readily available. Packages containing hazardous materials must not be banded, taped or strapped together. 172123, 55 FR 52602, Dec. 21, 1990, as amended at 56 FR 66261, Dec. 20, 1991]. The representation that a hazardous material is present in a package, container, rail car, aircraft, motor vehicle or vessel. In direct support of their farming operations; and. Registration is required annually and includes a fee. (c) For transportation by highway, a Division 5.2 placard conforming to the specifications in this section in effect on December 31, 2006 may continue to be used until January 1, 2014. These changes were first introduced in Docket HM-181 which provided for the harmonization of the United State's hazardous materials regulations with international standards in order to facilitate foreign trade and maintain the competitiveness of U.S. goods. (a) Except for size and color, the FLAMMABLE GAS placard must be as follows: (b) In addition to complying with 172.519, the background color on the FLAMMABLE GAS placard must be red. The 1,000 pound exception to placarding does not apply to these materials. (1) Investigation of known shipper violations discovered during carrier audits, (2) Non-frivolous written complaints alleging violations of the Federal Hazardous Materials Regulations, (3) NRC and DOT 5800.1, spill and hazmat incident reports, (4) Referrals from other governmental agencies and special investigations targeting high risk hazardous materials such as explosives and certain radioactive materials. TRANSPORTATION IN COMMERCE ON A PUBLIC HIGHWAY: Transportation on (across or along) roads outside of Government properties generally is transportation in commerce. However, there are some differences in the requirements for shipment by international air, international vessel, and shipments to and from Canada. The shipper must determine that the packaging or container is an authorized packaging, including all special requirements, and that the package has been manufactured, assembled and marked in accordance with the HMR. 172.504 Placarding Table 2. or more of a single category of HM is loaded on a transport vehicle, the placard specified for that material must be displayed. Both the DOT Hazardous Materials Table (49 CFR 172.101) and the IATA List of Dangerous Goods (IATA DGR 4.2) contain the entry Ammunition, SA (small arms). In both cases, the entries are followed by the words see Cartridges for weapons, etc.which means we are being redirected to another entry. The * shall be replaced with the appropriate division number and, when required, appropriate compatibility group letter. To avoid confusion about the type of packaging used for fully regulated shipments of Division 4.3 (Dangerous When Wet) or 6.1 (Toxic Substances - P.G. (See 49 CFR 107.606(a)(6) for exceptions and reciprocity.). The last two digits of the year of manufacture. 49 CFR 172.548 - DANGEROUS WHEN WET placard. - GovRegs 172.505 Placarding for subsidiary hazards. COMMERCIAL DRIVERS LICENSE REGULATION APPLICABILITY : THE RULES IN THIS PART APPLY TO EVERY PERSON WHO OPERATES A COMMERCIAL MOTOR VEHICLE IN INTERSTATE, FOREIGN, OR INTRASTATE COMMERCE AND TO ALL EMPLOYEES OF SUCH PERSONS. 172110, 52 FR 29528, Aug. 10, 1987; Amdt. No carrier may transport a hazardous material unless it is accompanied by a shipping paper that is prepared in accordance with the HMR. Specific gravity for packaging without inner linings designed to hold liquids rounded down to the first decimal for those nonviscous liquids having a specific gravity greater than 1.2. In addition to this section, shippers and carriers should check sections 177.834 through 177.854 for any additional handling requirements. The cookie is used to store the user consent for the cookies in the category "Other. Hazmat Labels and Marking for Shipments: What You Need - News and Info Burst Strength or 32 Edge Crush Test (ECT) certified box. Each person who offers hazardous materials for marine shall describe the dangerous materials on a shipping paper so conforms for the what of the HMR. 17229A, 41 FR 40679, Sept. 20, 1976]. (5) For transportation by transport vehicle or rail car only, an OXIDIZER placard is not required for Division 5.1 materials on a transport vehicle, rail car or freight container which also contains Division 1.5 explosives and is placarded with EXPLOSIVES 1.5 placards, as required. (i) The material being offered or transported is a hazardous material; (ii) The placard represents a hazard of the hazardous material being offered or transported; and. For an IBC labeled in accordance with subpart E of this part, the IBC may display the proper shipping name and UN identification number markings in accordance with 172.301(a)(1) in place of the UN number on an orange panel, placard or white square-on-point configuration as prescribed in 172.336(d); and. In addition, each placard made of tagboard must be able to pass a 414 kPa (60 p.s.i.) When using the aforementioned tables be sure to read the entire section, 178.848, and be aware that there are special instructions and exceptions listed. [Amdt. The purpose of these requirements is to enhance the security of hazardous materials transported in commerce. The shipper is responsible for determining the appropriate packing group. Security Training:Each hazmat employee must receive security awareness training. In addition to the provisions of 49 CFR Parts 100-180, interstate motor carriers of placarded loads must comply with the hazardous materials requirements in 49 CFR Part 397. Freight containers and aircraft unit load devices. (1) No motor carrier may transport a hazardous material in a motor vehicle, unless the placards required for the hazardous material are affixed thereto as required by this subpart. DIVISION 1.6 EXTREMELY INSENSITIVE EXPLOSIVES. Safety training:This training provides information concerning the hazards posed by materials in the workplace and personal protection measures. When Are HazMat Placards Required? - ICC Compliance Center Inc - USA 15, 1976, as amended by Amdt. These cookies help provide information on metrics the number of visitors, bounce rate, traffic source, etc. 172139, 59 FR 67490, Dec. 29, 1994]. Delivery of CAO shipments is not possible in some areas of Alaska. However, many states require military movements by highway to conform to 49 CFR or compatible state regulations. Electronic Code of Federal Regulations (e-CFR), Subtitle B - Other Regulations Relating to Transportation, CHAPTER I - PIPELINE AND HAZARDOUS MATERIALS SAFETY ADMINISTRATION, DEPARTMENT OF TRANSPORTATION, SUBCHAPTER C - HAZARDOUS MATERIALS REGULATIONS, PART 172 - HAZARDOUS MATERIALS TABLE, SPECIAL PROVISIONS, HAZARDOUS MATERIALS COMMUNICATIONS, EMERGENCY RESPONSE INFORMATION, TRAINING REQUIREMENTS, AND SECURITY PLANS. The carrier must check to insure that the material offered by the shipper is properly described and packaged. (1) The background color, symbol, text, numerals and inner border on a placard must be as specified in 172.521 through 172.560 of this subpart, as appropriate. Hazmat Placarding Guide: When and How to Label Cargo When a package is required to be marked with a UN standard or DOT specification, the package must meet all the requirements of the regulation, including testing. The international standards have general requirements for materials, construction and a maximum capacity as compared to detailed DOT specifications for non-bulk packagings formerly contained in 49 CFR, Part 178. (a) Except for size and color, the SPONTANEOUSLY COMBUSTIBLE placard must be as follows: (b) In addition to complying with 172.519, the background color on the SPONTANEOUSLY COMBUSTIBLE placard must be red in the lower half and white in upper half. "Persons" who offer for transportation, or transport in foreign, interstate or intrastate commerce: (a) any highway route controlled quantity of a Class 7 (radioactive) material; (b) more than 25 kg (55 lbs.) Any agency or instrumentality of the Federal government, for the purposes of 49 U.S.C. The phone number must be to someone capable of providing information on the material. 172130, 58 FR 51531, Oct. 1, 1993]. A comparison of the old and new classification system is contained in 173.53. They are placed on vehicles to warn people about the hazardous materials on or in that vehicle. For many materials, UPS requires the use of appropriate DOT special permit packages or packaging complying with 49 CFR 173.13. information or personal data. It is important to remember that except for materials in the U. N. Recommendations, the ICAO Technical Instructions, or the IMDG Code, a material that is not a hazardous material according to this sub-chapter may not be offered for transportation or transported when its description on a shipping paper includes a hazard class or an identification number specified in 49 CFR 172.101. The Electronic Code of Federal Regulations (eCFR) is a continuously updated online version of the CFR. The 12.5 mm measurement is from the outside edge of the placard to the outside of the solid line forming the inner border. Information that is available from the Table consists of: symbols that determine applicability, proper shipping name and shipping description, hazard class or division, identification number, packing group, label(s) required, special provisions, packaging authorizations, quantity limitations aboard aircraft, and vessel stowage requirements. 172123, 55 FR 52600, Dec. 21, 1990]. Materials of Trade means a hazardous material, other than a hazardous waste, that is carried on a motor vehicle--(1) For the purpose of protecting the health and safety of the motor vehicle operator or passengers; (2) For the purpose of supporting the operation of a motor vehicle (including its auxiliary equipment) or; (3) By a private motor carrier (including vehicles operated by a rail carrier) in direct support of a principal business other than transportation by a motor vehicle. Is Dot 3 flammable? 172123, 55 FR 52601, Dec. 21, 1990; 56 FR 66260, Dec. 20, 1991; 57 FR 45460, Oct. 1, 1992; Amdt. (1) Be securely attached or affixed thereto or placed in a holder thereon. (a) Capacity of 640 cubic feet or more. (b) In addition to complying with 172.519, the background color on the DANGEROUS WHEN WET placard must be blue. (a) Except for size and color, the DANGEROUS placard must be as follows: (b) In addition to meeting the requirements of 172.519, and appendix B to this part, the DANGEROUS placard must have a red upper and lower triangle. (2) A rail car loaded with transport vehicles or freight containers, none of which is required to be placarded. For content of report and additional information, please see 171.15. 1200 New Jersey Avenue SE, PHH-50 (1) Packagings must be leak tight for liquids and gases, sift proof for solids, and be securely closed, secured against shifting, and protected against damage. Other uncategorized cookies are those that are being analyzed and have not been classified into a category as yet. General placarding requirements are contained in 172.504. DIVISION 2.1 FLAMMABLE GASES This telephone number must be readily identifiable on the shipping paper. After March 25, 2003, hazmat employees must receive this training at their next scheduled recurrent training, but in no case later than March 24, 2006. A separate drafting site The term offeror means any person who performs, or is responsible for performing, any of the pre-transportation functions required under the HMR for transportation of a hazardous material; tenders or makes a hazardous material available to a carrier for transportation in commerce; or both performs, or is responsible for performing, pre-transportation functions and tenders or makes a hazardous material available to a carrier for transportation. No person may represent, certify, mark, sell or offer a packaging or container as meeting the requirements of the HMR, governing its use in transportation of a hazardous material, whether or not it is used or is intended to be used for transportation of a hazardous material, unless the packaging or container is manufactured, fabricated, marked, maintained, reconditioned, repaired or retested, as appropriate, in accordance with the HMR. (a) Except for size and color, the FLAMMABLE placard must be as follows: (b) In addition to complying with 172.519, the background color on the FLAMMABLE placard must be red. (See appendix C to this part. (Applies to commodities other than Dry Ice.). The shipper's responsibility is to classify and describe the HM in accordance with Parts 172 and 173. An HMSP is required to transport any of the following materials: Motor carriers will be required to apply for a HMSP the next time they are scheduled to file the MCS-150 form after January 1, 2005. [Amdt. The division numeral, 1.5, must measure at least 64 mm (2.5 inches) in height. All fully regulated shipments assigned to Division 6.1 (Toxic Substances - PG I or II), when offered at air or, All fully regulated shipments of Division 4.3 (Dangerous When Wet) materials, when offered at air or. This website uses cookies to improve your experience while you navigate through the website. May be offered for air service level only as Cargo Aircraft Only (CAO) shipments. border marker in the white area at each end of the inscription red. 172.555 POISON INHALATION HAZARD placard. border must be white. Why is hydroelectric energy not used more? Hazmat transportation regulations exceptionsWill one work for you? - BLR Packaging identification code consisting of: A letter identifying the performance standard. (2) The restrictions of paragraph (a) of this section do not apply to the display of a BIOHAZARD marking, a HOT marking, a sour crude oil hazard marking, or an identification number on a white square-on-point configuration in accordance with 172.323(c), 172.325(c), 172.327(a), or 172.336(b) of this part, respectively. Around which hazard classes must you never smoke? Search & Navigation Dangerous when wet - 4.3 Organic peroxide type B, liquid or solid, temperature controlled - 5.2 Materials poisonous by inhalation - 6.1; these are generally considered liquids or solids that are giving off fumes. 172143, 60 FR 50305, Sept. 28, 1995; 65 FR 50460, Aug. 18, 2000; 66 FR 33426, June 21, 2001; 66 FR 44255, Aug. 22, 2001; 67 FR 15743, Apr. The individual who signs the certification should be the individual most knowledgeable of the shipment. Does notapply to active duty military drivers. For more information or to ask questions related to the hazardous materials regulations call 1-800-467-4922 or contact PHMSA at: Pipeline and Hazardous Materials Safety Administration United Parcel Service of America, Inc. All rights reserved. If the package contains multiple hazmat materials, place the subsidiary . 172.512 Freight containers and aircraft unit load devices. [Amdt. and other generic descriptions, Organic peroxides to include concentration, All poisonous materials subject to 172.203(m) where the poisonous constituent is not mentioned in the proper shipping name, for materials meeting the definition of poison-inhalation hazard, (see 171.8) "Poison-Inhalation Hazard" as provided in 172.203(m) and the words "Hazard Zone A," "Hazard Zone B," "Hazard Zone C" or "Hazard Zone D" as appropriate. or existing codification. Business Hours:9:00am-5:00pm ET, M-F. Public Law 103-311 amended 49 U.S.C. The space below the vertical lines must be white with the class number 9 underlined and centered at the bottom. (7) For domestic transportation of oxygen, compressed or oxygen, refrigerated liquid, the OXYGEN placard in 172.530 of this subpart may be used in place of a NON-FLAMMABLE GAS placard. Refer to the most recent copy of the, UPS World Wide Express Freight (WWEF) service accepts Passenger Aircraft quantities (PAX) and Class 9 commodities prepared under Cargo Aircraft Only (CAO). 172123, 56 FR 66264, Dec. 20, 1991; Amdt. PDF DOT CHART 16 Hazardous Materials Markings,Labeling and Placarding Guide 17229, 41 FR 15996, Apr. 49CFR part 172.500 regulations dictate that Class 4 Dangerous When Wet placards have a blue background, and bare a Class 4 numeral code in white text. 172111, 52 FR 36671, Sept. 30, 1987; Amdt. here. A person receives an injury requiring admittance to a hospital; The general public is evacuated for one hour or more; A major transportation artery or facility is closed or shut down for one hour or more; or. P.O.P. Avoid placing it on the bottom of the package or device where it is less visible. Cross-border shipments of many Limited Quantity materials are allowed to many destinations in Canada and Mexico. Note: Cylinders must be overpacked in a container of suitable strength to retain its shape and protect operating mechanisms. All hazmat employees must have this training. 172.519 General specifications for placards. Materials transported domestically only, whose FPs are 100 F up to 141 F may be reclassified as combustible in accordance with 173.120(b). 1,001 POUNDS OR MORE A new hazmat employee who changes job functions may perform those functions prior to completion of training, provided the employee performs those functions under the direct supervision of a properly trained and knowledgeable hazmat employee; and the training is completed within 90 days after employment or job function. This provision is most frequently violated when the shipments involve non-RCRA Waste, which is not considered DOT hazardous materials. Recent changes include entries for: Technical names for n.o.s. Functional cookies help to perform certain functionalities like sharing the content of the website on social media platforms, collect feedbacks, and other third-party features. If more than one packing group is indicated for an entry, the packing group for the HM is determined using the criteria in 49 CFR, Part 173, Subpart D. General requirements are contained in 49 CFR 171.2(g). (c) The words FUEL OIL may be used in place of the word COMBUSTIBLE on a placard that is displayed on a cargo tank or portable tank being used to transport by highway fuel oil that is not classed as a flammable liquid. PACKAGE TESTINGconsists of the following: Design Qualification Testing, 178.601(c)(1); Periodic Retesting, 178.601(c)(2); Production Testing, 178.601(c)(3); Frequency of Periodic Testing, 178.601(e); Test Samples, 178.601(f). Official websites use .govA .gov website belongs to an official government organization in the United States. The placard center area and 12-inch (12.7 mm.) Dangerous when wet (4.3) Organic peroxide (Type B, liquid or solid, temperature controlled) (5.2) . Microsoft Edge, Google Chrome, Mozilla Firefox, or Safari. This list above contains some of the major responsibilities of HM carriers. (e) Form identification. The text, class number, and inner border must be black. Except as otherwise provided in this subchapter, each bulk packaging, freight container, unit load device, transport vehicle or rail car containing any quantity of a hazardous material must be placarded on each side and each end with the type of placards specified in tables 1 and 2 of this section and in accordance with other placarding requirements of this subpart, including the specifications for the placards named in the tables and described in detail in 172.519 through 172.560. However, a bulk packaging must be marked with the appropriate identification number on a CLASS 9 placard, an orange panel, or a white square-on-point display configuration as required by subpart D of this part. This may satisfy the hazardous materials training requirements. What do you need to know about shipping hazmat? Choosing an item from See 49 CFR 171.8 for more details about such materials. [Amdt. . Dangerous Goods of Class 4 Placards stating When Wet must be affixed in accordance with the legislation to all containers used for transporting hazardous goods.Carrying Dangerous Goods of the Class 4 When transporting wet hazardous commodities by roadway, train car, or cargo ship, it is imperative that the containers bear the appropriate Carrier and offeror (shipper) responsibilities frequently overlap. Amdt. Security Plan Applicability. Ground Service level shipments of Limited Quantity materials in the 48 contiguous states may be accepted at some locations. On a COMBUSTIBLE placard with a white bottom as prescribed by 172.332(c)(4), the class number must be red or black. Materials of Trade You are using an unsupported browser. Markings should be durable, in English, and not obscured by other markings or labels. The Secretary is authorized to issue regulations to implement the requirements of 49 U.S.C. The black vertical stripes must be spaced so that, visually, they appear equal in width to the six white spaces between them. (This substitutes for the lack of performance tests in UN standards with regard to puncture resistance, abrasion resistance and metal fatigue). 172123, 56 FR 66264, Dec. 20, 1991, as amended at 57 FR 45460, Oct. 1, 1992]. With the notation PG III appearing immediately adjacent to a TOXIC or POISON label. UPS does not accept any shipments of materials described as Toxic Inhalation Hazard materials. Weight: . Entries are required for number and type packaging and weight (net or gross). Written emergency response information must be appropriate for the hazardous material being transported. Out of these, the cookies that are categorized as necessary are stored on your browser as they are essential for the working of basic functionalities of the website. A highway route-controlled quantity of a Class 7 (radioactive) material; More than 25 kg (55 pounds) of a Division 1.1, 1.2, or 1.3 (explosive) material or an amount of a Division 1.5 (explosive) material requiring placarding under 49 CFR 172; More than one liter (1.08 quarts) per package of a "material poisonous by inhalation," that meets the criteria for "hazard zone A"; A "material poisonous by inhalation," that meets the criteria for "hazard zone B," in a bulk packaging (capacity greater than 460 L (119 gallons)); A "material poisonous by inhalation," that meets the criteria for "hazard zone C," or "hazard zone D," in a packaging having a capacity equal to or greater than 13,248 L (3,500 gallons); or. . 172.503 Identification number display on placards. (c) Exception for less than 454 kg (1,001 pounds). The records required by this rule must be produced upon reasonable demand by an authorized employee of the Department of Transportation. 172123, 55 FR 52602, Dec. 21, 1990, as amended at 56 FR 66260, Dec. 20, 1991]. Combustible, and Dangerous When Wet: Divisions 4.1, 4.2, 4.3 . Items 1-6 and thickness in millimeters must be applied in a permanent manner able to withstand reconditioning. Each red stripe and each white space between two red stripes must be 25 mm (1.0 inches) wide. The following additional markings are required: Name of the country in which the reconditioning was performed. EXPLOSIVES 1.1, EXPLOSIVES 1.2 and EXPLOSIVES 1.3 placards. 172.508 Placarding and affixing placards: Rail. However, a permanently affixed subsidiary placard meeting the specifications of this section which were in effect on October 1, 2001, (such as, a placard without the hazard class or division number displayed in the lower corner of the placard) and which was installed prior to September 30, 2001, may continue to be used as a subsidiary placard in domestic transportation by rail or highway, provided the color tolerances are maintained and are in accordance with the display requirements in this subchapter. Other Regulations Relating to Transportation, Pipeline and Hazardous Materials Safety Administration, Department of Transportation, Hazardous Materials Table, Special Provisions, Hazardous Materials Communications, Emergency Response Information, Training Requirements, and Security Plans, https://www.ecfr.gov/current/title-49/subtitle-B/chapter-I/subchapter-C/part-172/subpart-F. Applicability of placarding requirements.